Home > Products > Chemicals > Other Chemicals

1. PRODUCT INDENTIFICATION /GENERAL INFORMATION

Chemical Descrption:      Water-Gel Emulsion

Formula:                           Proprietary

Product Name:          Gel Cable Lubricant 0.33qt and 1qt

Product Type:        Cable Lubricant

2. COMPOSITION/INFORMATION ON INGREDIENTS

This product contains no reportable hazardous components under 29 CFR1910.1200.  There are no OSHA or ACGIH threshold limit values for the product or any of its ingredients.

3. HAZARDS INDENTIFICATION

Estimated NFPA Rating:                      Health 1, Flammability 0, Reactivity 0

Estimated HMIS Classification:                   Health 0, Flammability 0, Physical Hazard 0

  Key: 0-minimal  1-slight   2-moderate   3- serious   4- severe

  NFPA is a registered trademark of the National Fire Protection Association.

  HMIS Is a registered trademark of the National Paint and Coatings Association.

4. FIRST AID

Eye Contact:             Flush eyes with a large quantity of water for 15 minutes.

If irrtation continues, seek medical attention.

Skin Contact:                      If skin becomes irritated, wash area thoroughly with soap and water.

If irritation continues, seek medical attention.

Inhalation (Breathing) : No first aid expected to be required. Not an inhalation hazard.

Ingestion (Swallowing): No first aid expected to be required. If difficulties arise, contact a physician.

5. FIRE AND EXPLOSION HAZARD

Flash Point:                        No flash via COC method.                 

Flammable Limits: Product is not flammable.

Extinguishing Media:        Does not apply.                  

Special Procedures:         Does not apply.

Unusual Hazards:             Sealed container can build up pressure when exposed to high heat.

Cool contaners with water.

Hazardous Decomposition Products:

High temperature steam, potentially carbon monoxide and carbon dioxide.

6. ACCIDENTAL RELEASE MEASURES

FCC Gel cable lubricant is extremely slippery. It should be washed, swept, or squeegeed from floor using wet mops. Oxidizing agents, such as household bleach, can be used to eliminate the slippery character. Outside, spills should be covered with sand, dirt, gravel or calcium chloride.

7. HANDLING AND STORAGE

Handing:                     Avoid spills and clean them up immediately when they occur. Product is very slippery.

Storage:             Keep product containers closed when not in use. Store at temperatures between 40-180F. Avoid freezing.

Other Precautions: Keep away from children, Infants and pets.

8. EXPOSURE CONTROL / PERSONAL PROTECTION

Respiratory Protection: Normal ventilation adequate.

Ventilation :                          General ventilation is usually adequate.

Eye Protection:       Safety glasses(recommended) or splash goggles.

Protective Gloves:     For repeated or prolonged skin contact, the use of impermeable gloves

is recommended to prevent drying and possible irritation.

9. PHYSICAL AND CHEMICAL PROPERTIES

Appearance: light yellow gel

Odor: odorless

Boiling Point: 212°F  (~100℃)

pH: 6.5 to 7.5 (neutral)

Ignition Temperature: None

Specific Gravity (H₂O=1): 0.95±0.02

Percent Volatiles (Weight%): ＜90

Solubility in Water: moderate

10. STABILITY AND REACTIVITY

Stability: Stable at normal condition

Hazardous Polymerization: Will not occur

Incompatibility: Avoid materials that react with water.

Hazardous Products Formed by Fire or Thermal Decomposition: None

11. HEALTH HAZARD/TOXICOLOGICAL INFORMATION

Primary Routes of Entry: Inhalation and Skin Contact, Eye, Ingestion.

Eye Contact:                         Direct eye contact may cause eye irritation.

Skin Contact:              This product has low skin irritation potential. There is no dermal toxicity hazard.

Inhalation (Breathing):  No inhalation hazard expected with water vapor.

Ingestion (Swallowing): Based on ingredients, LD₅₀ (rat) is estimated to be well over 50g/kg.

Carcinogenic Status:    This substance has not been identified as a carcinogen or probable carcinogen by NTP,IARC or OSHA, nor have any of its components.

12. ECOLOGICAL INFORMATION

See Section 11

13. DISPOSAL CONSIDERATIONS

Waste Disposal Methods: Comply with federal,state, and local regulations for solid landfill. FCC gel cable lubricant is not considered hazardous under RCRA.

14. TRANSPORTATION INFORMATION

DOT(Department of Transportation)

Domestic Ground Transport

         DOT Shipping Name:        Unrestricted

         Hazard Class:                    None

         UN/ID Number:                  None

         Marine Pollutant:               None

Product Name: FCC Gel Cable Lubricant .33qt and 1qt.

15. REGULATORY INFORMATION

All components for this product are listed on the TSCA inventory. See Section 2

16. OTHER INFORMATION

Approved by: Chen Jin, Health and Safety Manager   Revision Date: 04/12/2006

Prepared by: Yang MengQing                                       Revision Summary: New MSDS

NA: Not Applicable   NDA: No data available   <: Less than   >: more than

We believe the statements, technical information and recommendations contained herein are reliable. However, the data is provided without warranty, expressed or implied. It is the user’s responsibility both to determine safe conditions for use of this product and assume loss, damage or expense, direct or consequential, arising from its use. Before using product, read lable.

Note:

^**   None of the chemical raw materials contained in this formulation are considered hazardous under the Federal Hazards Communication Standard 29 C. F. R 1910.1200

^***  Chemical Listed as Carcinogen or Potential Carcinogen.  [a] NTP  [b] ARC Monograph  [c] OSHA  [d] Not Listed  [e] Animal Data Only